Registration Dossier

Guidance on Safe Use

Guidance on Safe Use

Currently viewing:

Administrative data

First-aid measures

· General information: Do not leave affected persons unattended.
· After inhalation: Supply fresh air; consult doctor in case of complaints.
· After skin contact:
Immediately wash with water and soap and rinse thoroughly.
If skin irritation continues, consult a doctor.
· After eye contact:
Rinse opened eye for several minutes under running water.
Seek medical treatment.
· After swallowing:
Rinse out mouth and then drink plenty of water.
If symptoms persist consult doctor.
NOTE: Never give an unconscious person anything to drink.

Fire-fighting measures

· Suitable extinguishing agents:
The product is not flammable.
Use fire extinguishing methods suitable to surrounding conditions.
· For safety reasons unsuitable extinguishing agents: None
· Special hazards caused by the substance, its products of combustion or resulting gases:
During heating or in case of fire poisonous gases are produced.
Phosphorus oxides (e.g. P2O5)
Sulphur oxides (SOx)
Danger of toxic fluorine based pyrolysis products.
· Protective equipment:
Wear fully protective suit.
Mouth respiratory protective device.

Accidental release measures

· Person-related safety precautions:
Avoid formation of dust.
Ensure adequate ventilation
Use respiratory protective device against the effects of fumes/dust/aerosol.
· Measures for environmental protection: Do not allow product to reach sewage system or any water course.
· Measures for cleaning/collecting:
Pick up mechanically.
Damp down dust with water spray.
· Additional information: No dangerous substances are released.

Handling and storage

· Handling:
· Information for safe handling:
No special precautions are necessary if used correctly.
Prevent formation of dust.
· Information about fire - and explosion protection:
The product is not flammable.
No special measures required.
· Storage:
· Requirements to be met by storerooms and receptacles: Store in a cool location.
· Information about storage in one common storage facility:
Do not store together with alkalis (caustic solutions).
Do not store together with urea
· Further information about storage conditions:
Protect from heat and direct sunlight.
Protect from humidity and water.

Transport information

Shippingopen allclose all
SpecialProvisionsopen allclose all
Shippingopen allclose all
Remarksopen allclose all

Marine transport (IMDG)

Remarksopen allclose all
Remarksopen allclose all
SpecialProvisionsopen allclose all

Exposure controls / personal protection

· Additional information about design of technical facilities:
No further data; see handling and storage.
Ventilation must be sufficient to maintain TLV-TWA below 3 mg/m³, respirable particles, and 10 mg/m³,
inhalable particles [ACGIH recommendation for Particles (Insoluble or poorly soluble). Not Otherwise
Specified (PNOS)]
· Ingredients with limit values that require monitoring at the workplace: Not required.
· Personal protective equipment:
· General protective and hygienic measures:
The usual precautionary measures are to be adhered to when handling chemicals.
· Respiratory protection: Use suitable respiratory protective device in case of insufficient ventilation.
· Protection of hands:
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Due to missing tests no recommendation to the glove material can be given for the product/ the preparation/
the chemical mixture.
· Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of
quality and varies from manufacturer to manufacturer.
· Penetration time of glove material
The exact break trough time has to be found out by the manufacturer of the protective gloves and has to be
observed.
· Eye protection: Safety glasses
· Body protection: Light weight protective clothing
· Limitation and supervision of exposure into the environment
Based on all data available this product is of low hazard for the aquatic environment.
· Risk management measures
Exposure of the eye to dust at concentrations leading to irritation/corrosion during professional/consumer
use of this product can occur. When existing controls (i.e. engineering controls and personal protective
equipment based on classification and labelling of this product as causing serious damage to eyes) are
applied the substance is of no concern for workers.
· Additional information: For powder product: 0.80% by volume of sample was seen to be
< 10.00 μm.
The D10 was < 80.92 μm and D50 < 204.529 μm ( laser
diffraction particle analysis)
For granulated product: 0.8% by volume of sample was seen to
be < 1.0 mm.
The D10 was < 1.76 mm and D50 < 2.62 mm ( PSD analysis)

Stability and reactivity

· Thermal decomposition / conditions to be avoided:
No decomposition if used and stored according to specifications.
· Materials to be avoided:
Alkalis
Urea (Mixing with urea causes formation of very sticky urea phosphate.)
· Dangerous reactions Reacts with alkali (lyes).
· Dangerous decomposition products:
Formation of toxic gases is possible during heating or in case of fire.
Phosphorus oxides (e.g. P2O5)
Sulphur oxides (SOx)
Danger of toxic fluorine based pyrolysis products.

Disposal considerations

Product:
· Recommendation
Superphosphate is used as fertiliser. However, large spills can kill vegetation. Prevent large quantities from
entering waterways. If incontaminating, sweep up or collect, and reuse as product. If contaminated with
other materials, collect in suitable containers.
Smaller quantities can be disposed of with household waste.
Disposal must be made in accordance with Local Authority requirements.
· European waste catalogue
06 00 00 WASTES FROM INORGANIC CHEMICAL PROCESSES
06 09 00 wastes from the MSFU of phosphorous chemicals and phosphorous chemical processes
06 09 04 calcium-based reaction wastes other than those mentioned in 06 09 03
· Uncleaned packaging:
· Recommendation:
Packaging may be reused or recycled after cleaning.
Disposal must be made in accordance with Local Authority requirements.
· Recommended cleansing agents: Water, if necessary together with cleansing agents.